The1's Daily Daily Barina XC

Post Your Delco Powered Ride Here
User avatar
The1
Posts: 4694
Joined: Mon Jan 04, 2010 10:23 am

The1's Daily Daily Barina XC

Post by The1 »

Well my VS is now no longer needed for Daily, i have this beast, alot cheaper on fuel. VS Can be worked on without pressure of Daily Driver.

2004 Holden Barina XC (Opel Corsa C)
Z14XEP 1.4L 4cyl
5 Speed Manual

Found this out from a friend, been sitting in paddock under a tree for like 8yrs as old couple stopped driving, So scored it for nothing. Has 90,000km on it!!
Attachments
IMG_20191007_102026.png
IMG_20191007_102026.png (548.48 KiB) Viewed 8546 times
User avatar
The1
Posts: 4694
Joined: Mon Jan 04, 2010 10:23 am

Re: The1's Daily Daily Barina XC

Post by The1 »

Starting going through it, Alternator wasn't charging, only barely holding battery voltage, this car has one wire going to alternator from battery and another going to the main system, clamp meter is only showing 3amps from alternator being drawn and 8 from system. Alternator is a pain to change! The spring belt tensioner is a pain! Using a spring compressor to get it back into place. All charging fine now and at 14volts under load :thumbup: Atleast this car you can take the flaps off underneath and get half decent access to front of the engine, id still hate to do a water pump or timing chain on this thing.
Attachments
IMG_20190826_191833.png
IMG_20190826_191833.png (396.38 KiB) Viewed 8545 times
IMG_20190826_184107.png
IMG_20190826_184107.png (425.89 KiB) Viewed 8545 times
User avatar
The1
Posts: 4694
Joined: Mon Jan 04, 2010 10:23 am

Re: The1's Daily Daily Barina XC

Post by The1 »

an oil leak, common problem on these apparently the oil pressure switch leaks bad, new one installed now, gave the engine a degrease.
Attachments
IMG_20190825_220001.png
IMG_20190825_220001.png (426.21 KiB) Viewed 8545 times
User avatar
The1
Posts: 4694
Joined: Mon Jan 04, 2010 10:23 am

Re: The1's Daily Daily Barina XC

Post by The1 »

Key is stuffed so need to program a new one with tech2 but i need the pin code, car didn't come with manual or anything, bit of searching around if you pull the Siemens BCM from engine bay you can read the eeprom and get the pin. It's a 93c66. Pin was easy to find offset 52 and also 15F in plain text in ANSI view. All done!!
IMG_20191007_103240.png
IMG_20191007_103240.png (274.6 KiB) Viewed 8545 times
Bin File
93c66-barinaxc-16bit-BCM-pin1624.bin
(512 Bytes) Downloaded 362 times
IMG_20190908_154714.png
IMG_20190908_154714.png (332.96 KiB) Viewed 8545 times
IMG_20190908_1637151.png
IMG_20190908_1637151.png (464.17 KiB) Viewed 8545 times
User avatar
The1
Posts: 4694
Joined: Mon Jan 04, 2010 10:23 am

Re: The1's Daily Daily Barina XC

Post by The1 »

Anyone know how to read, write ECU in these? Im guessing MPPS V18 cable from some reading. Havn't been able to find anything for winols or tunerpro xdf. They are supposedly a bosch ME 7.6.1 ???

Ive pulled a same ECU from the wrecker and got pin code with this one supposedly.

Bosch 0261207721 is part also.
Attachments
IMG_20191007_104426.png
IMG_20191007_104426.png (447.07 KiB) Viewed 8545 times
User avatar
The1
Posts: 4694
Joined: Mon Jan 04, 2010 10:23 am

Re: The1's Daily Daily Barina XC

Post by The1 »

User avatar
delcowizzid
Posts: 5493
Joined: Sat Feb 28, 2009 8:38 pm
Location: Wellington NZ
Contact:

Re: The1's Daily Daily Barina XC

Post by delcowizzid »

I think my mpps v16 does 7.6.1 so 18 definately should
If Its Got Gas Or Ass Count Me In.if it cant be fixed with a hammer you have an electrical problem
User avatar
Gareth
Posts: 2502
Joined: Fri Mar 14, 2014 8:37 pm
Location: Bacchus Marsh, Vic

Re: The1's Daily Daily Barina XC

Post by Gareth »

Are they not essentially the same pcm as the VZ V6?
According to chemistry, alcohol is a solution...
User avatar
Gareth
Posts: 2502
Joined: Fri Mar 14, 2014 8:37 pm
Location: Bacchus Marsh, Vic

Re: The1's Daily Daily Barina XC

Post by Gareth »

Parts department of most Holden dealers will give you the immo code over the phone
According to chemistry, alcohol is a solution...
User avatar
The1
Posts: 4694
Joined: Mon Jan 04, 2010 10:23 am

Re: The1's Daily Daily Barina XC

Post by The1 »

thanks guys, looks like were onto something, barina on right and 2004 vz on left. all pin markings and everything are the same. Sounds like time to make up a loom and try reading one and flashing vz.
Attachments
IMG_20191007_203952.png
IMG_20191007_203952.png (553.56 KiB) Viewed 8508 times
Post Reply